Mighty-mule MM-SL2000B User Manual

Installation Manual for theSlide Gate Operator SystemPROFESSIONAL INSTALLATION RECOMMENDED!WARNING!This equipment is similar to other gate or door equ

IMPORTANT SAFETY INSTRUCTIONSviii SL-2000B Instruction Manual 04.26.12Required Safety Precautions for GatesInstall Screen Guard Over Gate and Fence

IMPORTANT SAFETY INSTRUCTIONS SL-2000B Instruction Manual 04.26.12 ixThese warning labels should be found at the locations specified below. If any

IMPORTANT SAFETY INSTRUCTIONSx SL-2000B Instruction Manual 04.26.12These warning labels should be found at the locations specified below. If any of

SL-2000B Instruction Manual 04.26.12 1Winter Ratings Watts Zone 1 Zone 2 Zone 3 SL-2000B 10 4 8 13SL-2000B 20 8 16 26Dual SL-2200B 2

2 SL-2000B Instruction Manual 04.26.12Gate Weight Gate Opening Gate Capacity Chart for SL-2000B Series (estimated number of cycles based on use wit

SL-2000B Instruction Manual 04.26.12 3SL-2000B PARTS IDENTIFICATION(4) 3/8”-16 x 2” diameter U-Bolts and (8) 3/8” Serrated Nuts (RB210)(2) Quick R

4 SL-2000B Instruction Manual 04.26.12SINGLE GATE OPERATOR INSTALLATIONGate PreperationOverview of Operator InstallationLevelPlumbConcreteConcreteBe

SL-2000B Instruction Manual 04.26.12 5CAUTION AUTOMATIC GATE STAND CLEAR 1-800-543-GATE ® Separate PVC Conduits for power and control wiring.Rolle

6 SL-2000B Instruction Manual 04.26.12Determining the Mounting Position and Mounting the OperatorStep 2Install chain brackets at each end of the gat

SL-2000B Instruction Manual 04.26.12 7Step 5 After the concrete has hardened, remove the string from the quick release pins. Attach the chain to o

Notes

8 SL-2000B Instruction Manual 04.26.12POWERING THE SYSTEMStep 1Make sure the control box power switch is in the OFF position.ON-OFFOFFStep 8Unscrew

SL-2000B Instruction Manual 04.26.12 9Connecting Solar Panel(s) (Only if transformer is not used)Insert one transformer wire into an 18VAC termina

10 SL-2000B Instruction Manual 04.26.12CONTROL BOARD SETTINGS 1234ONOBSTRUCTSENS.PULL/PUSHSEQ1SNGL/DUALSEQ2LEARNDIP switchesMIN MAXRED BLK ORG BLU G

SL-2000B Instruction Manual 04.26.12 11PotentiometersThe three (3) potentiometers on the control board operate like a volume control on a radio.

12 SL-2000B Instruction Manual 04.26.12Program Your Personal Transmitter SettingAll GTO transmitters are set to a standard code at the factory and a

SL-2000B Instruction Manual 04.26.12 13MOUNTING THE RECEIVERReceiver mountedon piece of woodReceiver InstallationCheck the range of the receiver b

14 SL-2000B Instruction Manual 04.26.12 Limit Nut BClosed position stop –if gate opens right to left.Open position stop –if gate opens left

SL-2000B Instruction Manual 04.26.12 15CONNECTING SAFETY DEVICESMake sure the control box power switch is OFF before connecting safety device wiri

16 SL-2000B Instruction Manual 04.26.12CONNECTING ACCESSORIESThe ACCESSORY terminal block is the connection point for accessories such as push butto

SL-2000B Instruction Manual 04.26.12 17ATTACHING THE HOUSINGMount the operator housing after all installation procedures are complete. Slide opera

SL-2000B Instruction Manual 04.26.12 iClass RatingThe GTO SL-2000B Gate Operator is intended for use with vehicular slide gates in single family r

18 SL-2000B Instruction Manual 04.26.12DUAL GATE SYSTEM INSTALLATION(4) 3/8”-16 x 2” diameter U-Bolts and (8) 3/8” Serrated Nuts (RB210)(2) Quick Re

SL-2000B Instruction Manual 04.26.12 19InstallPVCconduit(notincluded)neededforpowercablesandlowvoltagewiring–seeillustrationbelow.

20 SL-2000B Instruction Manual 04.26.12When the units are set in place and you have completed wiring the first unit follow the instructions below.Ste

SL-2000B Instruction Manual 04.26.12 21DIP SwitchesThe Control Board DIP switches must be set to accommodate your particular type of installation.

22 SL-2000B Instruction Manual 04.26.12MAINTENANCEMaintenance Schedule:•Testtheoperator,accessories,andsafetydevicesmonthly.•Servicethega

SL-2000B Instruction Manual 04.26.12 23WARRANTY AND REPAIR SERVICEIf your SL-2000B Gate Operator is not operating properly, please follow the step

24 SL-2000B Instruction Manual 04.26.12TROUBLESHOOTINGSYMPTOMS CAUSES CORRECTIVE ACTIONUnit clicks but does not operate• Gate binding or not slidin

SL-2000B Instruction Manual 04.26.12 25ACCESSORY CATALOGPOWERING ACCESSORIESLow Voltage Wire [RB509] The 16 gauge, stranded, dual conductor low vo

26 SL-2000B Instruction Manual 04.26.12Residential Wireless Entry Intercom Keypad [F3100MBC]Designed for added security to your automated gate with

SL-2000B Instruction Manual 04.26.12 27ADDITIONAL ACCESSORIESPhoto Beams [R4222]Primary “through beam” photo beam device. Provides “non-contact” e

ii SL-2000B Instruction Manual 04.26.12Thank you for purchasing a GTO/ACCESS SYSTEMS SL-2000B. When correctly installed and properly used, your SL-2

3121 Hartseld Road • Tallahassee, Florida, USA 32303 (850) 575-0176 • Fax (850) 575-8912Web site www.gtoaccess.com24/7 Troubleshooting Wizard: http:/

SL-2000B Instruction Manual 04.26.12 iiiTable of ContentsClass Rating ...

IMPORTANT SAFETY INSTRUCTIONSiv SL-2000B Instruction Manual 04.26.12Because automatic gate operators produce high levels of force, consumers need t

IMPORTANT SAFETY INSTRUCTIONS SL-2000B Instruction Manual 04.26.12 vFor The System DesignerWARNING: To reduce the risk of injury or death: 1. READ

IMPORTANT SAFETY INSTRUCTIONSvi SL-2000B Instruction Manual 04.26.12III. After Installation1. Attach the warning signs (included) to each side of

IMPORTANT SAFETY INSTRUCTIONS SL-2000B Instruction Manual 04.26.12 viiSecondary Means of Protection Against EntrapmentAs specified by Gate Operator